粉质黏土地层基坑渣土免烧砖配比及力学性能研究

doi:10.3973/j.issn.2096-4498.2020.S1.018

隧道建设（中英文） ›› 2020, Vol. 40 ›› Issue (S1): 145-151.DOI: 10.3973/j.issn.2096-4498.2020.S1.018

粉质黏土地层基坑渣土免烧砖配比及力学性能研究

姚清松¹, 蔡坤坤^¹, 刘超¹, 令凡琳^{2, *}, 王树英²

（1. 中交第三航务工程局有限公司交建工程分公司，上海 200940；2. 中南大学土木工程学院，湖南长沙 410075）

出版日期:2020-08-30 发布日期:2020-09-15
作者简介:姚清松（1982—），男，江苏淮安人，2004年毕业于中南大学，工程项目管理专业，本科，高级工程师，现从事隧道施工与管理工作。E-mail： 45009338@qq.com。 *通信作者：令凡琳， Email： lotusling@csu.edu.cn。

Study on Proportioning and Mechanical Properties of Unfired Bricks Based on Foundation Pit Muck in Silty Clay Stratum

YAO Qingsong¹, CAI Kunkun^1, LIU Chao¹, LING Fanlin^{2, *}, WANG Shuying²

（1. Communications Engineering Construction Branch of CCCC Third Harbor Engineering Co., Ltd., Shanghai 200940, China; 2. School of Civil Engineering, Central South University, Changsha 410075, Hunan, China)

Online:2020-08-30 Published:2020-09-15

摘要/Abstract

摘要： 基坑开挖过程中会产生大量渣土，为降低基坑渣土堆积、外运等对城市环境的影响，有必要对基坑渣土进行免烧砖制作技术研究。依托杭州地铁10号线某工区，基于均匀试验方法，设计并开展以粉质黏土为主要原料、水泥为胶凝材料、细砂为级配增强材料制备渣土免烧砖的配比试验，通过对试验结果进行线性回归和单因素分析，探究各因素对试样耐水性和抗压强度的影响规律。研究结果表明：采用粉质黏土地层基坑渣土制备的免烧砖，其软化系数随水泥和细砂占比增加而增大； 7 d抗压强度和28 d抗压强度随水泥占比增加而增大，随秸秆纤维占比增加而减小。在采用较优材料配比时，制得免烧砖软化系数大于0.8，7 d及28 d抗压强度均大于10 MPa，达到JC/T 422—2007《非烧结垃圾尾矿砖》MU10等级要求。

关键词: 粉质黏土, 基坑渣土, 再利用, 免烧砖, 配比设计

Abstract:

In the excavation process of foundation pit, a large amount of muck is generated. In order to minimize the influence of muck accumulation and transportation generated by foundation pit excavation, the technology of manufacturing unfired bricks by foundation pit muck should be developed. Hence, the proportioning test on unfired bricks with silty clay as main raw material, cement as cementing material, and fine sand as grading reinforcing material is designed by uniform test method based on a test area of Hangzhou Metro Line 10. Through linear regression and singlefactor analysis of test results, the influence of various factors on the water resistance and compressive strength of the samples are investigated. The results show that: (1) The softening coefficient of unfired brick prepared by foundation pit muck in silty clay stratum increases with the rise of cement and fine sand proportion. (2) The 7day and 28day compressive strengths increase with the rise of cement proportion and decrease with the rise of straw fiber proportion. When the better material ratio is adopted, the softening coefficient of unfired bricks is greater than 0.8, the 7day and 28day compressive strengths are greater than 10 MPa.

Key words: silty clay, foundation pit muck, recycling, unfired brick, proportioning design

姚清松, 蔡坤坤, 刘超, 令凡琳, 王树英. 粉质黏土地层基坑渣土免烧砖配比及力学性能研究[J]. 隧道建设, 2020, 40(S1): 145-151.

YAO Qingsong, CAI Kunkun, LIU Chao, LING Fanlin, WANG Shuying. Study on Proportioning and Mechanical Properties of Unfired Bricks Based on Foundation Pit Muck in Silty Clay Stratum[J]. Tunnel Construction, 2020, 40(S1): 145-151.

[1]	杜昌言, 朱汉标, 王树英, 张静珍. 泥水盾构泥饼分散崩解试验与应用研究[J]. 隧道建设, 2022, 42(5): 847-853.
[2]	谢亦朋, 张聪, 阳军生, 傅金阳, 肖超, 占永杰. Research and Prospect on Technology for Resource Recycling of Shield Tunnel Spoil(盾构隧道渣土资源化再利用技术研究及展望) [J]. 隧道建设, 2022, 42(2): 188-207.
[3]	李义华, 朱康康, 李明宇, 谭建兵, 张启瑞, 王增辉. 粉质黏土地层管幕+CRD法施工地表变形规律分析——以郑州地铁3号线中州大道站出入口通道工程为例 [J]. 隧道建设, 2022, 42(12): 2148-2156.
[4]	张亚洲，夏鹏举，魏代伟，姜腾，陈喜坤，陆帅. 南京纬三路过江通道泥水处理及全线路废弃土再利用技术[J]. 隧道建设, 2015, 35(11): 1229-1234.
[5]	沈景鹏 , 林华骏. 台北市大众捷运系统土地再利用新店机厂“美河市联合开发案”之规划及施工[J]. 隧道建设, 2010, 30(增刊1): 206-210.

粉质黏土地层基坑渣土免烧砖配比及力学性能研究

Study on Proportioning and Mechanical Properties of Unfired Bricks Based on Foundation Pit Muck in Silty Clay Stratum

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 5

编辑推荐

Metrics

本文评价