基于行车安全的ZJY高铁隧道底隆致无碴轨道变形处置实践与探讨

doi:10.3973/j.issn.2096-4498.2021.03.017

隧道建设（中英文） ›› 2021, Vol. 41 ›› Issue (3): 474-482.DOI: 10.3973/j.issn.2096-4498.2021.03.017

基于行车安全的ZJY高铁隧道底隆致无碴轨道变形处置实践与探讨

周保安¹，吴剑²，王立川^{3, 4, 5， *}，龚伦⁴，马相峰⁶，许召强²，赵伟⁵，张鹏¹

(1.中国铁路成都局集团有限公司，四川成都 610082； 2. 中铁西南科学研究院有限公司， 四川成都 611731； 3. 中南大学，湖南长沙 410075； 4. 西南交通大学，四川成都 610031； 5. 中铁十八局集团有限公司，天津 300222; 6. 中铁第四勘察设计院集团有限公司，湖北武汉 430063)

出版日期:2021-03-20 发布日期:2021-04-03
作者简介:周保安(1973—)，男，山西临猗人，2010年毕业于华东交通大学，交通运输专业，硕士，高级工程师，主要从事铁路工务和安全管理工作。E-mail： zba2001@126.com。*通信作者：王立川， E-mail： wlc773747@126.com。
基金资助:
国家自然科学基金资助项目(高铁联合基金)(U1934211)

Practice and Discussion on Treatment of Ballastless Track Deformation of a HighSpeed Railway Tunnel Caused by Floor Heave Based on Traffic Safety

ZHOU Bao′an¹, WU Jian², WANG Lichuan^{3, 4,
5, *}, GONG Lun⁴, MA Xiangfeng⁶, XU Zhaoqiang², ZHAO Wei⁵, ZHANG Peng¹

（1.China Railway Chengdu Group Co.,Ltd.,Chengdu 610082,Sichuan,China;2.China Railway Southwest Research Institute Co.,Ltd.,Chengdu 611731,Sichuan,China;3.Central South University, Changsha 410075, Hunan,China;4.Southwest Jiaotong University,Chengdu 610031,Sichuan,China;5.China Railway 18th Bureau Group Co., Ltd.,Tianjin 300222,China;6.China Railway Siyuan Survey and Design Group Co.,Ltd.,Wuhan 430063,Hubei,China)

Online:2021-03-20 Published:2021-04-03

摘要/Abstract

摘要： 为解决运营高铁隧道底隆导致无碴轨道变形影响行车安全的问题，以ZJY高铁隧道为对象，基于隧道底隆的处置实践过程与整治效果分析，对高铁隧道列车行车安全控制措施进行探讨，提出隧道底隆的预防与整治建议。主要结论有： 1）轨道顺坡精调只能短时缓解底隆导致轨道变形引起的轨道质量不良，而不能根除； 2）隧道底隆未根治而带缺陷开通运营，除导致工务维修工作量大幅攀升外，限速措施对运营秩序的冲击也不可小觑，底隆的最佳整治时间应在开通运营前； 3）正确勘察研判、针对性设计、严格科学施工是预防隧道底隆的前瞻性和根本性路径。实践证明：以隧底锚固为主要技术手段的整治方案对MPa级的高地应力型底隆是无效的，同时易产生不确定的行车安全风险；以辅助导坑进入正洞下方，构建柔性支护的中小断面导洞以阻断高地应力传递路径，是高地应力隧道底隆整治的方向性方案。

关键词: 高铁隧道, 底隆, 无碴轨道, 行车安全, 轨道顺坡精调, 隧底锚固

Abstract: The bottom heave of an operating highspeed railway tunnel induces deformation of ballastless track, and further affects traffic safety. Accordingly, the driving safety control measures of highspeed railway trains are discussed and some suggestions on the prevention and remediation of tunnel floor heave are put forward based on analysis of the treatment practice process of floor heave of a highspeed railway tunnel. The main conclusions are drawn as follows. (1) The fine adjustment of track along a slope can only relieve the poor track quality caused by floor heaveinduced track deformation temporarily, but cannot eliminate it. (2) If the tunnel is open for operation with bottom heave disease, not only the maintenance workload would be greatly increased, but the operation order would be greatly affected. The optimal rectification time for floor heave is before operation. (3) The prospective and essential way to prevent tunnel floor heave lies in accurate investigation and judgment, targeted design, and strict scientific construction. The practical results show that the treatment scheme with anchoring technology for tunnel floor heave is invalid under MPalevel geostress, whereas an assistant flexiblesupported small crosssection pilot tunnel will be a possible way to prevent tunnel floor heave under large geostress.

Key words: highspeed railway tunnel, tunnel floor heave, ballastless track, railway traffic safety, track fine adjustment along slope, tunnel bottom anchoring

中图分类号:

周保安, 吴剑, 王立川, 龚伦, 马相峰, 许召强, 赵伟, 张鹏. 基于行车安全的ZJY高铁隧道底隆致无碴轨道变形处置实践与探讨[J]. 隧道建设, 2021, 41(3): 474-482.

ZHOU Bao′an, WU Jian, WANG Lichuan, GONG Lun, MA Xiangfeng, XU Zhaoqiang, ZHAO Wei, ZHANG Peng. Practice and Discussion on Treatment of Ballastless Track Deformation of a HighSpeed Railway Tunnel Caused by Floor Heave Based on Traffic Safety[J]. Tunnel Construction, 2021, 41(3): 474-482.

[1]	TIAN Siming, WANG Wei, GONG Jiangfeng. Development and Prospect of Railway Tunnels in China (Including Statistics of Railway Tunnels in China by the End of 2020)（中国铁路隧道发展与展望（含截至2020年底中国铁路隧道统计数据）） [J]. 隧道建设, 2021, 41(2): 308-325.
[2]	TONG Jianjun, LIU Dagang, ZHANG Xiao, WANG Zhilong, ZHAO Siguang, LI Jiawang. Design Method for Support Structure of Large Crosssection Tunnels in Hubei on ZhengzhouWanzhou Railway Constructed by Mechanized Means（大断面隧道机械化施工支护结构设计方法）[J]. 隧道建设, 2021, 41(1): 116-125.
[3]	赵爽, 洪锦祥, 乔敏, 王伟, 曾鲁平, 赵斌. 早强型喷射混凝土在郑万高铁巫山隧道中的施工试验[J]. 隧道建设, 2020, 40(S1): 369-373.
[4]	韩华轩. Study on Selection of Tunnel Design Standard for Jakarta Bandung High speed Railway Project in Indonesia(印尼雅万高铁隧道设计技术标准的选择研究）[J]. 隧道建设, 2020, 40(6): 845-858.
[5]	王明年，赵思光，张霄. 郑万高铁大型机械化施工隧道位移控制基准研究[J]. 隧道建设, 2018, 38(8): 1271-1278.
[6]	李书兵. 软弱围岩隧道机械化全断面爆破开挖初期支护受力特性研究[J]. 隧道建设, 2018, 38(8): 1293-1302.
[7]	于丽，蔡闽金. 郑万高铁隧道大型机械化配套全断面法施工围岩-支护结构相互作用力学特性研究[J]. 隧道建设, 2018, 38(8): 1316-1323.
[8]	金强国. 郑万高铁隧道大型机械化施工支护优化[J]. 隧道建设, 2018, 38(8): 1324-1333.
[9]	赵宏博，卢伟. 三臂凿岩台车在郑万高铁隧道软弱围岩施工中的应用[J]. 隧道建设, 2018, 38(8): 1342-1349.
[10]	李洋，马留闯，王峰. 古夫隧道软弱围岩普通型机械化配套试验性施工技术[J]. 隧道建设, 2018, 38(8): 1371-1378.
[11]	王军,邱敬格,杨凡，王清朋，谭天乐. 隧道掘进爆破对某巨型干溶洞洞壁危岩体的扰动作用研究[J]. 隧道建设, 2018, 38(1): 41-49.
[12]	杨怀强, 陈建国. 双线铁路隧道双块式无碴轨道整体道床曲线段施工快速测量技术[J]. 隧道建设, 2010, 30(增刊1): 355-359.
[13]	王延民,奚正兵. 客运专线隧道无碴轨道底板施工技术[J]. 隧道建设, 2008, 28(2): 228-231.

基于行车安全的ZJY高铁隧道底隆致无碴轨道变形处置实践与探讨

Practice and Discussion on Treatment of Ballastless Track Deformation of a HighSpeed Railway Tunnel Caused by Floor Heave Based on Traffic Safety

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 13

编辑推荐

Metrics

本文评价